Environment

NGT panel flags environmental violations by ONGC, GAIL in Krishna-Godavari basin

Three units under them asked to pay Rs 17 crore in penalty to Central Pollution Control Board

 
By Kiran Pandey, Susan Chacko
Published: Friday 16 April 2021
__

Oil and Natural Gas Corp Ltd (ONGC) and GAIL Ltd prioritised production and extraction of oil and gas and did not pay attention to environmental and pollution mitigation measures in the Krishna-Godavari (KG) basin in Andhra Pradesh, flagged a report by the National Green Tribunal (NGT) April 13, 2021.

ONGC had on February 15 announced its plans to scale up gas production to two million metric standard cubic metres a day (MMSCMD) of natural gas from June-end from the $5.07 billion KG-DWN-98 / 2 project.

But the joint committee of the green tribunal formed September 8, 2020 has flagged concerns: It did so on the basis of two site visits conducted between December 8 and 11, 2020, and February 24 and 26, 2021.

The committee comprises senior officers from the Union Ministry of Environment & Climate Change (MoEF&CC), Chennai; Central Pollution Control Board (CPCB), Chennai; the Andhra Pradesh Pollution Control Board (APPCB); collector, East Godavari and West Godavari Districts and an expert from Andhra University College of Engineering, Visakhapatnam.

Agricultural land, water bodies polluted

The tribunal ordered for the constitution of the joint expert committee on September 8, after hearing a petition that alleged air, sound, soil and water pollution on the account of activities by GAIL India Ltd and ONGC units in Andhra Pradesh along the basin.

The petition alleged that the oil leakage in the pipelines of these units — Tatipaka group gathering station (GGS), Kesanapalli GGS and Odalarevu GGS — were damaging the farming land and affecting water bodies.

The report by green panel recommended that all three units should pay an environmental compensation of Rs 170,812,500 to CPCB for violation of environmental norms.

According to the committee, Tatipaka GGS will pay the highest penalty of Rs 72,862,500, followed by Odalarevu GGS (Rs 56,850,000) and Kesanapalli GGS (Rs 41,100,000)

The committee in its report stated that the effluent treatment plants (ETP) were not properly operated, and hazardous wastes such as ETP sludge, slop oil (crude oil emulsified with water and solid) was not disposed of according to the Hazardous Waste and Management Rules, 2011.

According to the report:

Hazardous effluents got mixed with storm water, especially during monsoons, it said. Around three acres of land in Tatipaka near the old ETP, and 10 acres of land in Odalarevu between GAIL and ONGC terminals, had high Chemical Oxygen Demand (COD), Biological Oxygen Demand (BOD) and Total Organic Carbon (TOC).

The unit should, therefore, ensure that effluent will not be allowed to mix with storm water, the report said.

Leak detection and repair (LDAR) — a process that helps reduce methane and VOC emissions from operations — had not been carried out.

High fugitive benzene emissions were found, in violation of the consent for operation (CFO) conditions by the Andhra Pradesh Pollution Control Board (APPCB).

The units were also accused of violating coastal regulation zone (CRZ) with respect to marine disposal of treated effluents at Kesanapalli, East Godavari.

It directed the Kesanapalli GGS immediately stop the disposal of treated effluent by marine outfall near the coast. Treated effluents should be disposed according to the conditions stipulated in CFO issued by APPCB.

Poor infrastructure

The committee flagged that the coal tar enamel (CTE) pipelines older than 30 years were still in use at the stations; CTE pipelines should not ideally be used for more than 20 years, the report stated.

Very old CTE-coated pipes may be replaced with a three-layer polyethylene (3LPE) pre-coated pipes.

A provision for gravel pack near the perforation to all flowing wells should be there to reduce entrainment of sand in pipelines and diminish the chances of pipeline leakage. But only nine of the 20 flowing wells had gravel pack as required, the report noted.

Natural gas produced from Kesanapalli GGS, Tatipaka and Gopavaram fields contained hydrogen sulphide (H2S) in the range of 15-50 parts per million from the flowing wells.

This gas needs to be treated to meet Petroleum and Natural Gas Regulatory Board guidelines of H2S concentration less than three ppm before supply to GAIL Ltd, according to the committee.

Mercury contamination

Around five acres of land in Kesanapalli GGS is also “probably contaminated with hazardous mercury”, since it was found to be present in the range of 201 milligrams per kilogram.

It is four-times more than the screening value of 50 mg for identifying a site as “probably contaminated site” according to the Union environment ministry.

Hence, the committee recommended that the unit should be directed to clean and restore the contaminated area, under supervision of APPCB.

Subscribe to Daily Newsletter :
Related Stories

India Environment Portal Resources :

Comments are moderated and will be published only after the site moderator’s approval. Please use a genuine email ID and provide your name. Selected comments may also be used in the ‘Letters’ section of the Down To Earth print edition.